| Author |
 Topic Search  Topic Options
|
coggonobrien 
Orange Level Access
Joined: 14 Nov 2010
Location: Eastern Iowa
Points: 1864
|
 Post Options
 Thanks(0)
 Quote  Reply
 Topic: 616 stumbling
Posted: 30 Jun 2016 at 6:57am |
just looking for suggestions, above 1/2 throttle the 616 starts missing. I've replaced the fuel filter, fuel lines, fuel pump (bypassed the mechanical and installed an electric), new carb I had alrady, new plugs, new plug wires. I need to run a volt test on the coil just to make sure 12v in 12v out. Only thing left to do is adjust timing and potentially replace the ignition box components. Any thoughts? Motor is not running rich.
Thanks David
|
 |
|
Sponsored Links
|
|
|
Tracy Martin TN
Orange Level Access
Joined: 11 Sep 2009
Location: Gallatin,TN
Points: 10830
|
Post Options
Thanks(0)
Quote Reply
Posted: 30 Jun 2016 at 8:46am |
|
I would spray Seafoam in it while it is running first. Might be carb adjustment, might be a little carbon buildup. If not, the points will probably be the culprit. Be safe and don't burn your hands. Tracy
|
|
No greater gift than healthy grandkids!
|
|
DSeries4
Orange Level
Joined: 12 Sep 2009
Location: Ontario, Canada
Points: 7530
|
Post Options
Thanks(0)
Quote Reply
Posted: 30 Jun 2016 at 9:15am |
|
Check for a bad spark plug. I put new ones in my 620 a few years ago and it would do what you describe at higher throttle. No problem at low throttle. Turns out one of the new plugs was bad. Replaced it and has run perfect since.
|
|
'49 G, '54 WD45, '55 CA, '56 WD45D, '57 WD45, '58 D14, '59 D14, '60 D14, '63 D15D, '66 D15II, '66 D21II, '67 D17IV, '67 D17IVD, '67 190XTD, '73 620, '76 185, '77 175, '84 8030, '85 6080
|
|
coggonobrien
Orange Level Access
Joined: 14 Nov 2010
Location: Eastern Iowa
Points: 1864
|
Post Options
Thanks(0)
Quote Reply
Posted: 30 Jun 2016 at 9:17am |
|
i've had 2 sets of new plugs in it
|
|
DSeries4
Orange Level
Joined: 12 Sep 2009
Location: Ontario, Canada
Points: 7530
|
Post Options
Thanks(0)
Quote Reply
Posted: 30 Jun 2016 at 9:27am |
|
What kind? Autolites are the ones that went bad in mine. I switched to NGK. I could tell the plug was no good because it was not as hot as the other one after running the engine.
That has been my only experience. Good luck in tracking down the problem.
|
|
'49 G, '54 WD45, '55 CA, '56 WD45D, '57 WD45, '58 D14, '59 D14, '60 D14, '63 D15D, '66 D15II, '66 D21II, '67 D17IV, '67 D17IVD, '67 190XTD, '73 620, '76 185, '77 175, '84 8030, '85 6080
|
|
tadams(OH)
Orange Level Access
Joined: 17 Sep 2009
Location: Jeromesville, O
Points: 11005
|
Post Options
Thanks(0)
Quote Reply
Posted: 30 Jun 2016 at 3:09pm |
Is your battery fully charged?
|
|
coggonobrien
Orange Level Access
Joined: 14 Nov 2010
Location: Eastern Iowa
Points: 1864
|
Post Options
Thanks(0)
Quote Reply
Posted: 30 Jun 2016 at 3:28pm |
|
battery is charged and for grins and giggles i put the battery charger on it while running, 40amp mode
|
|
coggonobrien
Orange Level Access
Joined: 14 Nov 2010
Location: Eastern Iowa
Points: 1864
|
Post Options
Thanks(0)
Quote Reply
Posted: 30 Jun 2016 at 3:28pm |
|
ngk plugs, won't touch autolite or champions
|
|
